How many gallons of coolant does a 2002 Ford Explorer take?
The 2002 Ford Explorer typically requires about 2 gallons (around 7.5 liters) of coolant to fill the cooling system. The exact amount depends on the engine type and configuration, so check your vehicle’s VIN-specific specifications for precision.
Engine options and cooling capacity
In 2002, the Explorer was primarily equipped with a 4.0-liter V6 in most configurations. Some trims or related models offered a larger V8 option, which affects the total cooling-system capacity.
Here are the typical capacities by engine configuration:
- 4.0L V6 engine: roughly 1.9–2.0 gallons (about 7.2–7.6 liters) for a full system fill, including radiator, hoses, and heater core.
- 4.6L V8 engine (less common on the Explorer lineup in 2002, but present on some related trims): about 2.3–2.5 gallons (about 8.7–9.5 liters).
Note: Exact capacity can vary by factory options, radiator size, and how the system is drained/refilled. For the most accurate figure, refer to the owner's manual or Ford's service data for your specific vehicle's VIN.
Bleeding and refilling considerations
When refilling, use a 50/50 mix of coolant and distilled water (or the manufacturer-recommended ratio) and bleed the system to remove air pockets. Start the engine with the radiator cap off or follow the bleed procedure in the manual, and monitor for leaks and temperature gauge behavior.
Summary
The 2002 Ford Explorer typically requires about 2 gallons of coolant, with a range of roughly 1.9–2.5 gallons depending on the engine configuration. Verify the exact figure for your specific vehicle to ensure a proper fill and safe operation.
Where does the coolant go in a 2002 Ford Explorer?
Next we need to get on top of the engine. And remove the coolant reservoir cap and place a funnel. Next we're going to replace the fluid that we removed. Earlier.
How many gallons does a 2002 Ford Explorer hold?
22.5 gal
Fuel & MPG
292.5/405.0 mi. 22.5 gal.
How many gallons of coolant does a Ford Explorer take?
Hello, you will need to obtain two gallons of green coolant and mix it with two gallons of water. A proper 50/50 mix is essential. You may not use all of it unless you also drain the block.
How many quarts does a 2002 Ford Explorer take?
5 quarts
